toyota revo factory defect(s) and major repairs

[revoGSX]

makikigaya lang ako sa MAC sa kabilang thread http://tsikot.yehey.com/forums/showthread.php?t=21509
very helpful yung info nila sa current and future adventure owners..

dito naman eh puro revo defects..

let me start for my 2003 Revo GSX 2.0 gas M/T

factory defect
1) aircon busted, leak on upper aircon hose at 15T km odometer/1.5years - toyota replaced the rubber hose and freon free of charge
2) moist on LH foglight after 1 year/10Tkm odometer - casa replaced it for free
3) back door noise/squeaks - for me, NOT a factory defect - kelangan lang regular ang paggamit ng WD40 or grasa dahil natutuyo and kelangan i-adjust ng tama yung hinges..

[revoGSX]

this is for my Dads 2000 Revo GL 2.4 diesel M/T

factory defects
1) Voltage regulator - (after 1 year) relay type on black metal box, casa replaced it free
2) Water leaking rear windshield/backdoor (after 2months) - casa resealed the rear windshield and replaced the damaged rear siding

Repairs done
1) sanden compressor outer bearing nasira (after 4.5years/75T km) - cost me 2K to replace/repair sa sanden quezon ave .. taga dito
2) nabutas muffler sa lugar ng rear wheels (after 4.5 years) - mga 2meters yata yung pinalitan sa nodalos
3) nag wiggle yung sanden compressor (after 5years/90T km) pero malamig pa din - beyond repair na, suspect ko is masikip yung aircon belt nung inadjust just a few months back lang.. cost us 5.5K for a surplus denso compressor including freon from Mang Mario ..malamig na ulit..
4) nabutas denso radiator ((after 5years/80T km) - overhaul at hinang sa shop ni zeagle .. mga P1.6K din yata gastos
5) nag-stockup yung right front disk (after 5years/90T km) - used a brake cylinder repair kit from casa

pero all orig pa rin ball joints nya and all underchassis parts..

[jonvic]

this is for my Dads 2000 Revo GL 2.4 diesel M/T

pero all orig pa rin ball joints nya and all underchassis parts..

sir, di pa rin napalitan yung mga wheel bearings nito?

[revoGSX]

sir, di pa rin napalitan yung mga wheel bearings nito?

sir twice na po napalitan front wheel bearings from year 2000, pati break pads din twice na din po...

[BoEinG_747]

sir twice na po napalitan front wheel bearings from year 2000, pati break pads din twice na din po...

every 3 years ba ang palit ng wheel bearings at brake pad? or depende sa mileage

[3sgTe]

i have too.. mine is VX240D 2004. the passenger door often squeaks with rust during every after rainy season... solved with wd40.. ok but still comes up during rainy season.. and also when turning hard curves may tunog ng steering na lumalagutok...???

[jonvic]

sir twice na po napalitan front wheel bearings from year 2000, pati break pads din twice na din po...

Thanks po sir revoGSX! Tama lang pala yung pagpalit ko recently ng bearings.. magpo-four years na rin kasi yung ride ko

[revoGSX]

yung palit ng bearings usually depende po sa road condition.. sobrang malubak lang talaga yung dinadaan ng 2000 revo diesel ni erpats hehe, pero yung sa 2003 gsx ko orig pa rin front wheel bearing (na-repack lang nun 20 at 40T kms sa toyota)

eto update:
2000 Revo GL Diesel M/T now at 120,000kms:
-pinalitan na ng brandnew na 3-row evercool radiator (mga around 5 to 6K) this march2007
-orig pa rin steering system nya pati alignment kahit ipa-check sa servitek eh good pa rin
-stuck-up yung front right brake.. lagi kasi nilulusong sa baha ng espana hehe, parang brake caliper repair kit ang ginawa

2003 Revo GSX M/T now at 50,000kms - wala pa ako major napagawa.. usual PMS lang sa toyota at spray ng wd40 sa backdoor hehe,
pati nga battery eh yung original na oriental battery pa.. one-click pa rin, add lang ako parati ng distilled water

[Aisel]

i have an SR '01, 2.0 EFI

factory defects, aircon louver lang po. hehe
tapos sa stock silver paint, sa stock bodykit, nagffade siya.

Repairs, maintenance so far:
1. Back door squeaks - madaling remedyohan
2. Radiator leak - after 7 years
3. tie rod and bearings - after 8 years
4. mga belts - after 7 years (ginamit hanggang masira. hehe)
5. exhaust muffler, resonator, pipe - after 8 years.

di ko nasukat by mileage kaya by year na lang. hehe.

click here to see sira sa exhaust, grabe talaga...

http://www.cardomain.com/ride/3342597

[revoGSX]

wala na ibang nag-post..

so ako lang pala meron factory sa revo namin hehe